sail-world.com
 
 
News Home Cruising Photo Gallery Video Gallery
Sail-World.com : Boat painting - simple but best tips
Boat painting - simple but best tips

'The mast before'    .    Click Here to view large photo

Andrew Keays from Artful Dodger, contributing member of the Island Cruising Association, here suggests some simple but best techniques for painting your boat, in this case using International Brand paint, but the advice is good for any brand.

Introductory Notes:
- Perfection is a 2-pack paint designed for application by brush or roller (as opposed to spraying).
- Perfection is not recommended for timber surfaces, which like to flex and move – use a good single pack.
- Do NOT put 2-pack over single pack – if you already have single pack, sand back to the original material (eg Glass).

The mast after.jpg -  .. .   Click Here to view large photo


Surface Preparation:
- Whenever you prepare a surface for painting, clean it with wax and grease remover before you sand. This way you don’t embed grease into the prepared surface.
- Sand with 240 paper (not 400) to give your surface enough grip on the paint.
- Clean again with wax and grease remover, and before painting use a tack cloth to get rid of all the dust you can.

Bow roller -  .. .   Click Here to view large photo


Paint Preparation:
- Use International Thinners no 6 (not 9). The can is marked for use with single pack paints only, but the suggestion comes from International Paints at Coomera and it lets the paint hold a wet edge for a lot longer.

- Open and stir Part A, but do not open Part B. Instead use a Phillips head screwdriver to poke holes in the lid either side far enough away from the edge to give you a smooth surface to tape over after use. When you have poured the required amount of Part B apply masking tape to the holes and invert the can once to form a seal over the holes. Then it will be usable again next time rather than completely mangled (as the lids are apparently designed not to come off in one piece!)

- Use 10% thinners 6 (for the reasons previously described).

Just look at the gloss on this -  .. .   Click Here to view large photo


Paint Application
- Do not paint in the wind, direct sun or on a moist morning. Wait until around 10am when the dew has gone. Paint in the shade – rig up tarps as best you can.

- Use yellow 10' Haydn rollers. Other rollers slowly dissolve.

- We suggest using a flat surface to roll paint onto the roller – corflute or something similar – so the roller has an even covering of paint, not too much. Trial and error will show you the way.

Cabin tops before -  .. .   Click Here to view large photo


- Use Perfection undercoat. Do not put too much paint on, it will run.

- Paint about 600 mm at a time maintaining a wet edge. Get an even coverage then go back and 'tip off' with the roller, just rolling over lightly to blend the new 600mm into the last 600. Do not go back and try to correct earlier areas painted as you will wreck the finish. The paint will gradually settle into a perfect finish as a bit of time passes.1

Cabin tops after -  .. .   Click Here to view large photo


- The undercoat is important. It will probably take at least 2 coats to get even coverage. If not, do it again until you have coverage. The Perfection top coat is quite transparent and any areas of dubious coverage will show through 2 coats of gloss.

- When the paint is dry, sand it (with 240) and apply the top coats, sanding between all coats.

About the Island Cruising Association:
The Island Cruising Association (ICA) offers an ever growing knowledge-base of cruising resources and information specific to Extended Coastal in New Zealand and Australia and Offshore, with an emphasis on the South West Pacific. They run a wide range of fun events, training, practical demonstrations, on the water preparation and back up to assist cruisers to get out there, and a growing range of rallies, just for cruising sailors. Of note is the NZ2OZ rally for International, New Zealand and Australian cruisers from Opua in NZ up to Vanuatu and across to Darwin in time to join Sail Indonesia out of Darwin. For more information go to the ICA website.

Hung up to dry -  .. .   Click Here to view large photo


by Andrew Keays, Island Cruising Association


  

Click on the FB Like link to post this story to your FB wall

http://www.sail-world.com/index.cfm?nid=120061

1:32 AM Wed 12 Mar 2014GMT


Click here for printer friendly version
Click here to send us feedback or comments about this story.







News - USA and the World

America's Cup: Rod Davis - Time for a change after ten years with team *Feature by Richard Gladwell/Sail-World.com/nz,




AWT Quatro Desert Showdown at Punta San Carlos by American Windsurfing Tour,
























Maxi yacht rendezvous this September in Sardinia by International Maxi Association,




















America's Cup: Team NZ wish Davis well with new team *Feature by Richard Gladwell, Sail-world.com/nz,


Fisher's View: Sailing perfection at Hamilton Island- Day 3 by Bob Fisher, Hamilton Island, Queensland




2014 Formula Kite World Championship Day 1 by Markus Schwendtner, Istanbul












Nanjing Youth Olympic Games - Improvements aplenty in Byte CII fleets
America's Cup: New Zealand loses top coach to Artemis Racing
Volvo Ocean Race 2014-15 CEO Knut Frostad talks (Part I) *Feature
Sevenstar Round Britain and Ireland Race Day 9 - Swish on record pace
2014 CORK Olympic Classes Regatta - Day 3
2014 Nanjing Youth Olympic Games - Day 2
2014 IFDS World Championship: Opening Ceremony images
Opera House Cup - Images by Ingrid Abery
Teams descend upon Cowes for inaugural J/111 World Championships
Hamilton Island Race Week: Everywhere there's smiley people
IFDS World Championships - US Paralympic hopefuls ready for racing
Sopot Match Race - Poland's Tour debut deemed a triumph
Vineyard Race celebrates 80th running of the East Coast classic
Nanjing Youth Olympic Games: Young sailors begin racing on Lake Jinniu
AWT Quatro Desert Showdown - Victory for Morgan Noireaux
Sevenstar Round Britain and Ireland Race - Day 8: Test of endurance
Bart's Bash: Over 2300 entered from 588 yacht clubs - Join here
Halifax ready to welcome the world at 2014 IFDS World Championships
RC44 World Championship title to Bronenosec + Video
Audi Hamilton Island Race Week: Day 2 Images by Crosbie Lorimer
IFDS Worlds - Gary Jobson to attend opening ceremonies   
Melges 32 U.S. National Championship - Dalton DeVos crowned champion   
2014 Nanjing Youth Olympic Games trailer   
2014 Chicago Grand Slam - Canfield wins   
Round Britain and Ireland Race - Varuna takes overall lead   
Audi Hamilton Island Race Week; Crosbie Lorimer Day 1 Images   
Fisher's View: Hamilton Island Race Week - Day 1 - Stayin' Alive   
CORK Olympic Classes Regatta 2014 - Day one   
Youth Olympics: practice over, athletes welcomed, time for YOG sailing   
Round Britain and Ireland Race - Record for Artemis-Team Endeavour   
2014 Melges 32 U.S. National Championship - Day 2   
Sevenstar Round Britain and Ireland: Artemis sets fourth course record   
2014 Chicago Grand Slam - Top seeds survive as semi-finalists   
420 and 470 Junior Europeans - Breezy day 4 in Gdynia   
RC44 World Championship - Dramatic improvement for Artemis Racing   
18' Skiff International Regatta - Action begins August 25th   
Round Britain and Ireland Race - Challenging conditions arise   
Round Britain and Ireland Race - Record-breaking monohull victory   
Round Britain and Ireland Race - Dongfeng Race Team finishes third   
RC44 Marstrand World Championship - Bronenosec the star performer   


For this week's complete news stories select    Last 7 Days
   Search All News
For last month's complete news stories select    Last 30 Days
   Archive News







Sail-World.com  


















Switch Default Region to:

Social Media

Asia

Australia

Canada

Europe

New Zealand

United Kingdom


http://www.sail-world.com/event_images/image/Twitter_logo_small.png http://www.sail-world.com/event_images/image/FaceBook-icon.png  http://www.sail-world.com/event_images/image/RSS-Icon.png

United States

Cruising Northern

Cruising Southern

MarineBusiness World

PowerBoat World

FishingBoating World

 

Contact

Commercial

News

Search

Contact Us

Advertisers Information

Submit news/events

Search Stories/Text

Feedback

Advertisers Directory

Newsletter Archive

Photo Gallery

 

Banner Advertising Details

Newsletter Subscribe

Video Gallery

Policies

 

 

 

Privacy Policy

 

 


Cookie Policy

 

 



This site and its contents are © Copyright TetraMedia and/or the original author, photographer etc. All Rights Reserved.  Photographs are copyright by law.  If you wish to use or buy a photograph contact the photographer directly.
XLXL NEW US
LocalAds   DE  ES  FR  IT