sail-world.com
 
 
News Home Cruising Photo Gallery Video Gallery

 

Sail-World.com : Lewmar Deck Switch Advisory Notice

Lewmar Deck Switch Advisory Notice

.
Electric deck switches operate in a hostile environment and are subject to salt water, extremes of temperature, direct sunlight and UV effect. They are also susceptible to wear and tear following repeated use and can in some instances suffer accidental damage during boat operations. It is therefore recommended that regular visual and functional inspection of the switch, the circuitry and the equipment being controlled is carried out by a competent qualified person on a regular basis.

If any defects are noted on the switch (see point 2.0 below), replacement is mandatory so as to avoid the possibility of a malfunction. It is further recommended that an item of this nature is not intended to remain in service forever. The lifespan will depend upon the weather and UV conditions to which the switch is exposed as well as the amount of use. Therefore, a service lifespan of 3 to 5 years from date of purchase can be expected, after which time it should be replaced. Shorter lifespans could be experienced and the following inspection recommendations are therefore important in ensuring continuing safe operation.

Inspection
1.0 The deck switch and the system it controls should be fully tested in a ‘No Load’ condition prior to full functional operation as per it’s design purpose, before every trip, activity or task. Only after the skipper has satisfied themselves of the safe and functional operations should the equipment be used.

2.0 The deck switch should be inspected pre-departure or use paying particular attention to the following:
2.1 Ensure there is no visible damage to the switch
2.2 Ensure there is no noticeable wear to the switch, it’s housing, it’s button or fixings
2.3 Ensure the rubber membrane over the switch is not sticky or has any deposits or residue from cleaning fluids or other prohibited materials
2.4 Ensure the rubber membrane over the switch does not show any signs of cracks, splits or signs of degradation. This includes a change in colour from shiny to a matt finish
2.5 The main switch housing should not have any visible chips or cracks
2.6 The switch should have a smooth positive feel with a distinct click that can be felt at the point of operation
2.7 There should be no signs of water ingress on any part of the switch assembly
2.8 Ensure that the fixings screws and seal to the deck bulkhead or coach roof are secure, and remain effective in both securing the switch and preventing water ingress
2.9 The switch should not feel spongy and should not make a squelch or bubbling noise due to water ingress when depressed and operated

Note
If any of the points highlighted in 2.0 through to 2.9 are detected during inspection, the deck switches should not be used and should be replaced.

3.0 On an annual basis the deck switch should be removed by a qualified electrical technician to carry out the following:
3.1 All the checks detailed in 2.0 – 2.9 of this product service update
3.2 Inspect the underside of the deck switch for signs of corrosion, damage or water ingress
3.3 Inspect the wiring for signs of loose connections or corrosion
3.4 In open circuit mode (OFF) condition the resistance should be checked for a recording on the test meter beyond measurement to confirm no electrical connection.
3.5 In closed circuit mode (ON) condition, the resistance should be less than 3 ? (ohms)
3.6 If the switch shows any signs of excessive wear, degradation in it’s action, water ingress or loss in it’s electrical resistance properties, it should be changed immediately

Additional Guidance
4.0 It is the responsibility of the skipper to ensure that crew members are trained in the operation of powered deck equipment and use it in a safe and appropriate way within it’s designed operating parameters. This includes what to do in an emergency.

4.1 It is the responsibility of the skipper to ensure that crew members are appropriately briefed on all three methods of equipment isolation in event of emergency, i.e :-
4.1.1 The switch itself and it’s operation
4.1.2 The circuit breaker on main panel
4.1.3 The main battery isolation

4.2 Crew briefings should always cover the following issues pertaining to deck switch operated equipment:-
4.2.1 Safe operation of any powered deck equipment.
4.2.2 What to do in the event of an emergency
4.2.3 What not to do in event of emergency
4.2.4 A practical demonstration of the effective isolation of deck equipment as highlighted in point 2 above

4.3 Deck switches are designed to be used in conjunction with Lewmar equipment only. If they are to be used for the powering of any other electrical equipment the intended use should be checked against the specification of the switch.
4.4 Deck switches should only be operated with fingers, bare feet or soft soled shoes.
4.5 Switches should be left with the lid closed to minimise environmental degradation and the potential for accidental operation.
4.6 Powered deck equipment should always be isolated when not in use to prevent accidental start up.
4.7 The instructions for the equipment being operated should always be read and followed.
4.8 Power washers should not be used on or near any switch.
4.9 It is acknowledged that deck switches will need to be washed down as part of a deck cleaning process.
However, direct flow from a non pressure hose should not be aimed at the switch.
4.10 The deck switch itself should only be cleaned with a mild soap and washed off immediately with a light application of fresh water.

4.11 The following (non exhaustive) list of substances should not be applied, or used on or near any deck switch. Products include but are not limited to:-
4.11.1 Chemicals
4.11.2 Deck cleaners
4.11.3 Petroleum based fluids/cleaners
4.11.4 Deck polish
4.11.5 Deck brightener
4.11.6 Varnish/lacquers/paints
4.11.7 Oil

Specific Considerations for Winch Operation Manual B2303 Issue 7

Winch Operation
Please ensure that you thoroughly understand the operation and safety requirements of the winch before commencing the installation. Only persons who are completely familiar with the controls and those who have been fully made aware of the correct use of the winch should be allowed to use it. If there is any doubt of how to install or operate this unit please seek advice from a suitably qualified engineer.

• Winches used incorrectly could cause harm to equipment or crew.

• Winches should be used with care and treated with respect.

• Sailing, like many other sports can be hazardous. Even the correct selection, maintenance and use of proper equipment cannot eliminate the potential for danger, serious injury or death.

• Lewmar winches are designed and supplied for line control in marine applications and are to be used in conjunction with appropriate clutches, cleats and other manual controls and stoppers.

• It is the unavoidable responsibility of the owner or master or other responsible party to assess the risk of any operation on the vessel.

• Under no circumstances should any self tailing winch be used in self tailing mode for any lifting operation;
rather suitable and adequate manual tailing should be arranged with proper means of manually cleating or stopping the hoist.

• Every winch should be installed with adequate means of manually cleating or stopping the loaded ropes.

Specific Considerations for Windlass Operation Manual 65001201 Issue 2

Windlass Operation
Classification Societies and Lewmar require that a vessel at anchor must have its rode held by a chain stopper or equivalent strong point at all times!

At all times it is the responsibility of the boat user to ensure that the anchor and rode are properly stowed for the prevailing sea conditions. This is particularly important with high-speed powerboats, because an anchor accidentally deploying while under way can cause considerable damage. An anchor windlass is mounted in the most exposed position on a vessel and is thus subject to severe atmospheric attack resulting in a possibility of corrosion in excess of that experienced with most other items of deck equipment. As the windlass may only be used infrequently, the risk of corrosion is further increased. It is essential that the windlass is regularly examined, operated and given any necessary maintenance.

Please ensure that you thoroughly understand the operation and safety requirements of the windlass before commencing the installation. Only persons who are completely familiar with the controls and those who have been fully made aware of the correct use of the windlass should be allowed to use it. If there is any doubt of how to install or operate this unit please seek advice from a suitably qualified engineer.

• Windlasses used incorrectly could cause harm to equipment or crew.

• Windlasses should be used with care and treated with respect.

• Sailing, like many other sports can be hazardous. Even the correct selection, maintenance and use of proper equipment cannot eliminate the potential for danger, serious injury or death.

• Lewmar windlasses are designed and supplied for anchor control in marine applications and are not to be used in conjunction with any other use.

• It is the unavoidable responsibility of the owner or master or other responsible party to assess the risk of any operation on the vessel.

Additional Information
Lewmar recommends the use of appropriate Personal Protective Equipment and hands free communication equipment by any person going aloft, and only then where the person going aloft is properly trained in the use of that equipment and where there remain sufficient trained and experienced personnel on deck to ensure constant observation and the continued safe conduct both of the vessel and the hoisting operation.

Lewmar website




by Lewmar Marine

  

Click on the FB Like link to post this story to your FB wall

http://www.sail-world.com/index.cfm?nid=85246

10:34 AM Tue 28 Jun 2011 GMT






Click here for printer friendly version
Click here to send us feedback or comments about this story.


News - USA and the World

Rolex Sydney to Hobart: Replay video coverage on Sail-World *Feature by Richard Gladwell/Sail-World.com/nz
Replay of the start of the 2014 Rolex Sydney to Hobart Race. The fleet is expected to experience fresh to strong headwinds for the start and first 24 hours, although winds will moderate towards the end of this period. ... [more]  

Will Comanche take a scalp? by Rob Kothe and the Sail-World Team
After blasting off the startline earlier today, Jim Clark's Comanche continues to hold the lead in the 2014 Rolex Sydney Hobart race eight hours into the race. ... [more]  

A stiff southerly is testing the boats and sailors on the first afternoon of the 2014 Rolex Sydney Hobart and by late afternoon, four yachts had retired from the Cruising Yacht Club of Australia’s annual race. The first casualties of the race were Tina of Melbourne, forced out because of hull damage and Bear Necessity with a damaged rudder, just two hours into the race. ... [more]  

2014 Rolex Sydney Hobart Yacht Race: The 117 competing yachts, including five 100-foot Maxis, represents the race’s largest number of starters since 1994. Of the five Maxis, Jim Clark’s Comanche (USA) made the early gains in the race’s 70th edition, reaching the first mark in record time and setting a blistering pace. Seven-time line honours winner Wild Oats XI was in close pursuit. ... [more]  

Top international photographers, Carlo Borlenghi and Daniel Forster were on the water, and in the air, for the start of the 70th edition of the Rolex Sydney Hobart Race. Here is a selection of their images of the day. ... [more]  

Rolex Sydney Hobart Yacht Race 2014 - Start photos by Andrea Francolini. ... [more]  

Comanche skipper Ken Read was in fine form in this video interview. He says On the first night, will there will be too much upwind to be able to send it? It absolutey plays on my mind as the skipper this boat is untested. We’re completely cutting edge, and when it's cutting edge it’s a Formula 1 race car that blows up its engine on the first lap. ... [more]  

Rolex Sydney Hobart Yacht Race: Brad Kellett, Brindabella’s sailing master, reported that while he was doing his regular checks this evening he discovered larger than normal quantities of water in the bottom of the boat, found to be coming from damaged rudder bearings. 'We were just coming into our own after a risky tactical decision to go offshore paid off,' a disappointed Kellett said. ... [more]  

Rolex Sydney Hobart Yacht Race - Day 1 start images by photographer Carlo Borlenghi ... [more]  

One of the largest fleets in many years started the 70th Rolex Sydney Hobart Yacht Race today in a building southerly and in bright sunshine. There seemed to be some mind games going on amongst the super maxis during the pre race dry runs as each in turn put in a single reef in the 30 minutes before the start. Possibly there was some tossing of the coin as to whether it was ... [more]  

Rolex Sydney Hobart Yacht Race 2014 - Tony Cable just keeps going on. Last year he finished his 48th Sydney Hobart, setting a record for the number of races by an individual - this year it is number 49 - 49 not out, just one off the half ton! ... [more]  

Rolex Sydney Hobart Yacht Race: Designed for fast broad reaching, the 15 knot plus south-easterly breeze on the harbour was made to order for the big red and black hulled yacht owned by American Jim Clark and his Australian wife, Kristy. After a brilliant start slightly ahead and to leeward of Wild Oats XI, Comanche swiftly unfurled her giant spinnaker and took off, quickly ‘rolling the Oats’. ... [more]  

America’s Cup winning skipper Jimmy Spithill could well be the most overqualified grinder you’ll see in action in the Cruising Yacht Club of Australia’s Rolex Sydney Hobart start line today. 'He’s been a wonderful team player and literally in the pre-start you’re going to see him grinding, he said he’d do whatever it takes, and he’s lived up to that,' Comanche skipper Ken Read said. ... [more]  

Expect a spectacular and very fast start down Sydney Harbour in the Rolex Sydney Hobart Yacht Race this year. At the final briefing for crews at the Cruising Yacht Club of Australia this morning, the Bureau of Meteorology’s Andrew Treloar told the sailors that a southerly front is expected to move through Sydney about an hour before race start. ... [more]  

Chicken pies, the gooseneck and the voodoo stick were the last items to be ticked off today in Wild Oats XI’s preparation for a record-breaking bid in the Rolex Sydney Hobart race, which starts on Sydney Harbour at 1pm tomorrow. ... [more]  

The 2014 Rolex Sydney Hobart coverage will go live at 0800 AEST with interviews, but will play the promo until then. ... [more]  

In the media scrum for interviews with the skippers and owners of the five super maxis that followed a short press conference at the CYCA on Christmas Eve, anyone from outside the yachting scene might not have noticed one of the world’s finest sailors and circumnavigators standing quietly to one side chatting with Iain Murray and Steve Jarvin ... [more]  

America’s Cup winning skipper Jimmy Spithill could well be the most overqualified grinder you’ll see in action in the Cruising Yacht Club of Australia’s Rolex Sydney Hobart start line today. 'He’s been a wonderful team player and literally in the pre-start you’re going to see him grinding, he said he’d do whatever it takes, and he’s lived up to that,' Comanche skipper Ken Read said. ... [more]  

When most would have been sitting down for Christmas lunch the Wild Oats XI team were to be seen out on Sydney Harbour testing their new - and appropriately named - gooseneck, that replaces the one that failed when out training earlier in the week. In a puffy nor'easter Wild Oats XI headed to Manly on the wind, swung around close to the Manly East mark and headed back down the harbour for home. ... [more]  

Rolex Sydney Hobart Yacht Race 2014 - The Weather Gate *Feature by John Curnow and Rob Kothe, Sydney
In order to win this iconic ocean race,on handicap, there are three things you absolutely need to have accomplished. Two you can do something about, whereas the third is entirely out of your control. ... [more]  

For Christmas a Shiny new Sail-World.com *Feature by Brendan Maxwell
Santa’s elves started on January 7th 2014 building a set of shiny new Sail-World.com websites and just minutes before Christmas morning in one of Santa’s first touch downs Auckland New Zealand , TetraMedia General Manager Jedda Murphy flicked the switch on the dedicated TetraMeda servers in Frankfurt Germany to take almost all our world-wide audience to the new Sail-World sites. ... [more]  

Professor Pat Pending had the most amazing Convert-a-Car in the 60s cartoon series, the Wacky Races. It could do just about anything. Come Boxing Day and the start of the 70th Sydney-Hobart, some may well wish they had a Convert-a-Boat. Being a hundred feet at the start would be cool. You get away off your own line and in clear breeze. You’re also well inside the rulebook. ... [more]  

Few Americans have won more sailboat races than Ken Read, 53, the President of North Sails . Read is skipper of Comanche, Jim and Kristy Clark’s new 100-fooer, one of five that will be lining up on the startline of the Sydney to Hobart. I caught up with Read some 48 hours before the start to get his pulse on the race, Comanche, and the adventure that lies ahead, en route to Hobart. ... [more]  

The skippers of the five 100 foot super maxis battling for Line Honours in the Rolex Sydney Hobart Yacht Race speak about the boats, the weather and their expectations. ... [more]  

For sure Christmas is upon the 16 skippers of the Barcelona World Race, but the way they enjoy it or deal with it will be different from team to team, and skipper to skipper. But for everyone the thoughts of the 31st December start, and what lies ahead for the coming three months, are impossible to suppress. Even on Christmas Day. ... [more]  

Volvo Ocean Race: Team Vestas Wind recovery video *Feature by Richard Gladwell/Sail-World.com/nz
Three and a half minute video of the Team Vestas Wind recovery operation from the reef at St Brandon. The Volvo Ocean Racer struck the reef on November 29, just after nightfall breaking off both rudders, she also ;ost a considerable part of her stern section. ... [more]  

The magnitude of this 70th edition is reflected in the size of the international fleet: the forecast 117 race entrants, comprising yachts from seven different countries, represents the most sizeable Rolex Sydney Hobart depart since 1994. 'This year is both the 70th edition of the race and the 70th anniversary of the Cruising Yacht Club of Australia,' explains John Cameron. ... [more]  

The lightest of the supermaxi's Syd Fischer's Ragamuffin 100 suffered a major structural deck failure in pre-Hobart training. Sailing master David Witt explains in his usual laconic manner just what happened. ... [more]  

2014 Rolex Sydney Hobart Yacht Race - Sydney Hobart yacht race record holder, Wild Oats XI, is the centre of an intense repair effort on the eve of the big race after suffering damage during her most recent training run. ... [more]  

2014 Rolex Sydney Hobart Yacht Race images are provided by Photographer Carlo Borlenghi. ... [more]  

Images of five faces behind the 100ft super maxis taking part in the 2014 Rolex Sydney to Hobart provided by Photographer Andrea Francolini. ... [more]  

2014 Rolex Sydney Hobart Yacht Race - Sailors in this year’s Rolex Sydney Hobart should watch what they eat on Christmas day or they may well watch Christmas dinner all over again on Boxing Day. ... [more]  

Launched in September 2014, Comanche resulted from the studies realised on the Macif and Banque Populaire Imoca monohulls, who finished first and second in the 2012 Vendée Globe. ... [more]  

Olympic Sailing Waters - Rio de Janeiro
St. Maarten Heineken Regatta - Holiday gifts for a range of entries!
2014 Rolex Sydney Hobart Yacht Race - To Hobart in Style
Rolex Sydney Hobart Race: Ken Read's notes on Comanche
Rolex Sydney Hobart: Rio 100 - A supermaxi is reborn + Video *Feature
Volvo Ocean Race: Video of Team Vestas Wind being removed from reef
St. Maarten Heineken Regatta - Holiday gifts for a range of entries!
Entries open for 2015 ORC Championship events
Rolex Sydney Hobart - Levelling the playing field
Rolex Sydney Hobart Yacht Race video preview
Rolex Sydney Hobart Yacht Race - It's a Woman’s world too
Moth Worlds – Looping the loop *Feature
Miami Winter Series - M32 racing gets underway
Rio 2016 - Super-bugs found in Rio sailing waters
Building the bridge from Optimist to Laser and beyond – with Byte C1 *Feature
Kieler Woche - Notices of Race published – entry systems are now open
Adventures of a Sailor Girl: News and interviews from December 22 show
RORC Transatlantic 2014 Race Lanzarote-Grenada - Overall report
Volvo Ocean Race: Team Vestas Wind images from the reef recovery
Volvo Ocean Race: Team Vestas Wind recovered from reef
RORC Transatlantic Race 2014 - Prizegiving   
Qingdao to continue as Asian ISAF Sailing World Cup venue   
2014 Rolex Sydney Hobart Race - Will it be Bash and Crash?   
Rolex Sydney Hobart Race: USA's RIO 100 trains off Sydney Heads   
Rolex Sydney Hobart Race - Weather early Xmas gift for small yachts   
2014 Rolex Sydney Hobart Yacht Race - Hollywood focused on victory   
Soldiering on in the 70th Rolex Sydney Hobart Yacht Race   
Mount Gay Round Barbados Race Series - Count down to Caribbean opener   
Barcelona World Race 2014-15 - The mental game + Videos   
Rolex Sydney Hobart: Jim Clark's thoughts on Comanche's maiden race *Feature   
St Thomas International Regatta announce sponsors   
2014 Rolex Sydney Hobart Yacht Race - Salt water therapy   
Soto 40 South American Tour - Coming soon   
Flying Dutchman Worlds on Sydney Harbour   
Moth Tutorials - Presented by Nathan Outteridge   
America's Cup: Full CAS report finds both ISAF and de Ridder at fault *Feature   
2014 Rolex Sydney Hobart Yacht Race – One race many nations   
ORC announces new ORCsy rule for superyachts   
Rob and Scarlet’s big adventure before Rolex Sydney Hobart Yacht Race   
Waypoints of the 2014 Rolex Sydney Hobart Yacht Race   


For this week's complete news stories select    Last 7 Days
   Search All News
For last month's complete news stories select    Last 30 Days
   Archive News







Sail-World.com  


















Switch Default Region to:

Social Media

Asia

Australia

Canada

Europe

New Zealand

United Kingdom


http://www.sail-world.com/event_images/image/Twitter_logo_small.png http://www.sail-world.com/event_images/image/FaceBook-icon.png  http://www.sail-world.com/event_images/image/RSS-Icon.png

United States

Cruising Northern

Cruising Southern

MarineBusiness World

PowerBoat World

FishingBoating World

 

Contact

Commercial

News

Search

Contact Us

Advertisers Information

Submit news/events

Search Stories/Text

Feedback

Advertisers Directory

Newsletter Archive

Photo Gallery

 

Banner Advertising Details

Newsletter Subscribe

Video Gallery

Policies

 

 

 

Privacy Policy

 

 


Cookie Policy

 

 



This site and its contents are © Copyright TetraMedia and/or the original author, photographer etc. All Rights Reserved.  Photographs are copyright by law.  If you wish to use or buy a photograph contact the photographer directly.
XLXL NEW US
LocalAds   DE  ES  FR  IT