sail-world.com
 
 
News Home Cruising Photo Gallery Video Gallery
Sail-World.com : Five simple checks to troubleshoot your outboard
Five simple checks to troubleshoot your outboard

'Outboard - why the &%$@ won’t it start?'    .

You may know how to sail brilliantly, but that doesn't mean that you can solve problems with the outboard motor on your dinghy or tender, particularly if you are mechanically challenged. Here are five common problems and simple fixes which might get you back home one day(if you're a natural Mr/Ms Fixit, skip this story):

1.) Motor completely dead, won’t start:

If it is completely dead and you believe that the battery should have at least a little charge in it, here are some checks:
a. Make sure the throttle is in neutral
b. Is the ignition switch loose? This could be the problem, and is easily remedied by tightening the screws.
c. Do you have a 'battery selector switch?' - make sure it is turned to 'on'.
d. Is there a 'kill switch'? check that it is not disconnected.

2.) Dying boat battery:
If a boat grinds in trying to start, but the battery quickly withers and dies, at least you know the battery connections are making some contact. Still, check wire leads from the motor to the battery, and tighten them, since running bumpy water often can loosen battery lug nuts.

If lugs/nuts are corroded heavily, scrape off gunk with a knife or screwdriver (wire brush is best), and wipe clean. Check the connections again for tightness, and if possible spray on oil like WD40 to battery terminals to improve conductivity.

3.) Dead cranking battery:
The battery is cranking okay but the motor won't start. Trade it with another on-board 'hot' battery that may be used for an electric motor or other electronics. A set of battery cables is valuable boating equipment, and they may be used for 'jumping' a dead cranking battery with a charged one, even from another boat if you can summon on-the-water help.
Another possible solution to a dead battery may be a burned-out fuse. Know where boat fuses are located.

4.) Fouled propeller:
It's so easy to get a fishing line wrapped around a boat motor propeller, no matter the size of type of the motor. Monofilament line is bad enough, and fine, braided line is even worse. Line can work deeply into a propeller seal, and ruin a motor. So get it out soon, and thoroughly. Sometimes simply pulling on an end of a fishing line removes it from a propeller. The motor may need to be put in 'neutral' for a prop to spin freely as line is pulled.

With most weeds, even tough-stem bulrushes and pads, normally they can be removed by hand after a motor has been hauled up to expose its prop. However, occasionally fouled weeds or line are well out of reach of people in a boat. If you can reach shore, work the motor into the shallows, get out and remove fouled material.

In deep, open water, it may be easiest to free a big motor propeller from in the water. While wearing a life preserver, ease overboard and have a look at the prop.

5.) Engine overheats:
Never ignore this, as you can overheat and ruin an otherwise perfectly good engine. Check the water intake on the motor near the propeller. Usually it’s just weeds or it could be a plastic bag blocking water flow.

Occasionally, especially on smaller outboards, the water outflow nozzle at the bottom-rear of the cowling can become plugged, and must be opened for clean water flow.

This and the intake ports can be cleared of debris with heavy single-gauge wire (number 14 electrical) or even with heavy monofilament line (50 to 100 pound test).


by Des Ryan

  

Click on the FB Like link to post this story to your FB wall

http://www.sail-world.com/index.cfm?nid=100675

12:09 AM Mon 6 Aug 2012GMT


Click here for printer friendly version
Click here to send us feedback or comments about this story.

Click for further information on
Practical

Related News Stories:

06 Aug 2012  Cruising spinnakers made easy - hoist from cockpit
03 Aug 2012  Product of the Week: The Sailchute
25 Jul 2012  Product of the Week: A radar reflector for your grab bag
25 Jul 2012  Product of the Week: A radar reflector for your grab bag
02 Jul 2012  Five knots you can't leave home without!
01 Jul 2012  Product of the Week: Occasional solar power
30 Jun 2012  Looking after the timber on your sailing boat
18 Jun 2012  Five bits of gear I wish I'd known about before I left to go cruising
05 Jun 2012  Product of the Week: Tide Application for iPads
03 Jun 2012  Product of the Week: Self-fit terminals
MORE STORIES ...






News - USA and the World



























Starboard Hatteras Wave Jam day 5 by American Windsurfing Tour,


















470 Men and Women Worlds - Champions decided in Santander by International 470 Class Association,






















Royal Cup Marina Ibiza - No racing on penultimate day
Belcher takes record fifth 470 World Championship
ISAF Sailing World Championships - Santander - Day 8 video highlights
2014 Great Lakes Team Racing Championship about to set off
2014 Etchells North American Championship - Day 1
2014 U.S. Multihull Championship - Day 1
2014 Chicago Match Cup - Repechage top four determined in final flight
J/24 World Championship - 35th anniversary preview
470 Men and Women Worlds - Santander medal race line-up confirmed
ISAF Sailing Worlds, Santander - Day 8 images by Sail-World.com
Royal Cup Marina Ibiza - Quantum Racing stumbles in coastal race
ISAF Sailing Worlds, Santander - Americans ready for 470 medal races
ISAF Sailing Worlds, Santander: Action ramps up with end zone in sight
Big Boat Series - It's not the size, it's the length
ISAF Sailing World Championships Santander - Double French RS:X gold
ISAF Sailing Worlds, Santander - Day 8 images by Sailing Energy
ISAF Sailing Worlds - Finn leaders emerge from shifty Santander breeze
ISAF Sailing Worlds, Santander - RS:X winner images by Barbara Sanchez
ISAF Sailing Worlds, Santander - Rio 2016 470 spots awarded
52 Super Series 2015 - Outlook looks hot for the 52 Super Series
Starboard Hatteras Wave Jam - Another early start on day 4   
ISAF Sailing World - First entry leaves sailor's reputation in tatters   
2014 Chicago Match Cup - Four go through to quarter finals   
470 Men and Women Worlds - Champs take over leaderboard   
ISAF Sailing World Champ - Buckingham finishes with career-best result   
America's Cup: Oracle's Larry Ellison to step down as CEO   
Classic Yacht Regatta - Sonny takes top classic prize   
ISAF Sailing Worlds, Santander - Buckingham finishes with career best   
ISAF Sailing Worlds, Santander - Rio 2016 RS:X spots claimed   
ISAF Sailing Worlds - Leaderboards shaping up in Santander + Video   
ISAF Sailing Worlds, Santander - Giles Scott continues to extend lead   
ISAF Sailing Worlds, Santander - Day 7 images by Sailing Energy   
ISAF Sailing Worlds - Laser and Radial winner images by Jesus Renedo   
ISAF Sailing Worlds, Santander - Medal Race images by Sail-World.com   
ISAF Sailing Worlds - Dutch dominate Laser and Radial in Santander   
Royal Cup Marina Ibiza - Quantum Racing more than doubles overall lead   
J/24 World Championship - Excitement builds for Newport racing   
Volvo Ocean Race - Seb Marsset joins Team Alvimedica   
Fall Seamanship training opportunities at New York Yacht Club   
Rolex Big Boat Series: More images from San Francisco - Final Day   


For this week's complete news stories select    Last 7 Days
   Search All News
For last month's complete news stories select    Last 30 Days
   Archive News







Sail-World.com  


















Switch Default Region to:

Social Media

Asia

Australia

Canada

Europe

New Zealand

United Kingdom


http://www.sail-world.com/event_images/image/Twitter_logo_small.png http://www.sail-world.com/event_images/image/FaceBook-icon.png  http://www.sail-world.com/event_images/image/RSS-Icon.png

United States

Cruising Northern

Cruising Southern

MarineBusiness World

PowerBoat World

FishingBoating World

 

Contact

Commercial

News

Search

Contact Us

Advertisers Information

Submit news/events

Search Stories/Text

Feedback

Advertisers Directory

Newsletter Archive

Photo Gallery

 

Banner Advertising Details

Newsletter Subscribe

Video Gallery

Policies

 

 

 

Privacy Policy

 

 


Cookie Policy

 

 



This site and its contents are © Copyright TetraMedia and/or the original author, photographer etc. All Rights Reserved.  Photographs are copyright by law.  If you wish to use or buy a photograph contact the photographer directly.
XLXL NEW US
LocalAds   DE  ES  FR  IT