Please select your home edition
Edition
Fever-Tree 728x90

Effects of Ethanol E10 on the outboard - the real story

by BoatUS on 30 Mar 2012
Old outboards are the ones which suffer most problems with E10 SW
Ever since E10 gasoline (gas containing 10% ethanol) became widely available several years ago, the USA's largest recreational boat owners group, BoatUS, has received hundreds of calls and emails complaining about boat engine problems. The majority of complaints concern older outboard motors, those made before about 1990.

BoatUS' Seaworthy magazine asked Mercury Marine's Ed Alyanak and Frank Kelley, who between them have over 60 years of experience, to find out what's made these decades-old outboards more susceptible to ethanol's well-known problems and what owners can do.

1. Vulnerable hoses:

In the mid 1980's new standards (SAE J1527) for fuel hoses were developed for 'gasohol,' which was known to deteriorate rubber and plastics. Since then, problems with hoses have largely gone away, but that doesn't mean they are maintenance free. Tech Tip: Any hose older than 10 years should be replaced. Here's another way to test rubber fuel hose condition: wipe a clean rag along the hose. If you smell gas on the rag, replace the hose immediately.

2. Carburetors:

O-rings and rubber carburetor parts on older engines tend to get hard and brittle when exposed to ethanol and then break off in bits and pieces causing clogs, misfires and shutdowns. Pre-1990 carburetors were also made from alloys that didn't stand up to ethanol, leading to corrosion that can cause tiny fuel orifices to clog, resulting in hard starts and poor running. Old carbs are also 'dumb' in that they were designed to run on only one type of fuel. Ethanol, however, has more oxygen and affects the air/fuel ratio, causing engines to run leaner and hotter. Tech Tip: The best solution with old outboards is to run straight gas - if you can find it. Some mechanics may also have the ability to 'recalibrate' a carburetor to tolerate E10 (note: gas with ethanol greater than 10% should never be used with any boat engine).

3. Plastic fuel filter bowl:

Some older engines may have plastic fuel filter bowls. Tech Tip: If you still have one, replace immediately with a metal bowl.

4. Fuel fill gasket:

Keeping water out of the fuel tank is even more important with ethanol as it can eventually lead to the formation of two separate solutions in the gas tank (water and fuel), also known as phase separation. The process is more common on older boats which are more likely to have accumulated water at the bottom of the tank. Once phase separation happens - the tipping point when water in the gas is either harmlessly ingested or transformed into a corrosive mixture no engine will run on - there's no going back. No fuel additive can restore E10 back to its normal state. Tech Tip: Age and exposure to ethanol can rot fill gaskets or O-rings. Replace them every few years.

5. 'Gunk' in the tank:

It is still possible that some old outboards and boat fuel systems have yet to sip a drop of E10. But once your boat drinks its first tankful, ethanol will 'scour' or dissolve the gunk that's been coating the tank walls (and hoses) for years. Tech tip: You may want to think about hiring a professional to have the tank drained completely of any gas and water at the bottom before adding your first load of E10. If not, keep a supply of filters on hand - they will clog quickly. Always use a fuel stabilizer and avoid using octane boosters that contain ethanol.

For more information on ethanol and boat engines, go to http://www.BoatUS.com/seaworthy/ethanol.asp.
PredictWind.comZhik AkzoNobelb 660x82Wildwind 2016 660x82

Related Articles

Boat International partners with NZ Millennium Cup 2018
Boat International partners with NZ Millennium Cup 2018 to celebrate superyacht regatta’s tenth anniversary Boat International Media, the global authority on superyachts and the luxury lifestyle that goes with them, has today announced that it will be partnering with the NZ Millennium Cup superyacht regatta, to be held in New Zealand’s Bay of Islands in January 2018.
Posted on 22 Apr
A Few Rays - What is Broad Spectrum Protection?
What is Broad Spectrum sunscreen? Ultraviolet rays only make up a small proportion of all of the sun’s rays. What is Broad Spectrum sunscreen? Ultraviolet rays (UVA, UVB and UVC) only make up a small proportion of all of the sun’s rays. UVA and UVB sun-rays are however the biggest contributors to skin damage from sun.
Posted on 19 Apr
Coast Guard urges boating safety common sense
Coast Guard reminds mariners that as the air temperature is warming the water temperatures are still dangerously cold The Coast Guard is reminding mariners Friday that as the air temperature is warming the water temperatures are still dangerously cold. With the rise in air temperature, the number of boaters, paddle craft users, and water enthusiasts taking to water activities also rises.
Posted on 15 Apr
A very difficult day - Got fuel to Cape Town
Well after my dismasting I have spent the last two days motoring North towards Cape Town trying to collect myself Well after my dismasting I have spent the last two days motoring North towards Cape Town trying to collect myself and to intercept Hong Kong container ship M/V Far Eastern Mercury who had been diverted by Maritime Rescue Coordination Center Cape Town (MRCC Cape Town) when I had issued a Pan-Pan during my dismasting.
Posted on 8 Apr
Lisa Blair heads to Cape Town under motor following dismasting
A PAN PAN was called at 0300 (AET) / 1900 (SAST) signalling an urgent threat to her safety and this remains in place. Lisa Blair has assessed the damage to her yacht, Climate Action Now, after being dismasted 895 nm south of Cape Town in 40 knot winds and seven metre swells early in the morning of April 4, 2017. She made a PAN PAN call over the radio at approximately 0300 (AET) / 1900 (SAST) signalling an urgent threat to her safety and this remains in place.
Posted on 4 Apr
A Few Rays- Calculate how long your sunscreen lasts.
Confused by SPF's? It’s easy to calculate how long you will be protected by using the following process. Exposure to the sun is a serious issue for all those who venture on the water. Confused by SPF's? It’s easy to calculate how long you will be protected by using the following process.
Posted on 2 Apr
Coast Guard joins Arctic stakeholders in historic forum
U.S. Coast Guard Commandant Adm. Paul Zukunft joined leaders representing eight coast guards of Arctic nations U.S. Coast Guard Commandant Adm. Paul Zukunft joined leaders representing eight coast guards of Arctic nations in signing a joint statement Friday. The statement adopts doctrine, tactics, procedures and information-sharing protocols for emergency maritime response and combined operations in the Arctic. The Arctic Coast Guard Forum is an operationally-focused, consensus-based organisation...
Posted on 24 Mar
Coast Guard Foundation announces tribute in New Orleans
Coast Guard Foundation announced that its Tribute to the Coast Guard District will be held at the National WW II Museum The Coast Guard Foundation, a non-profit organization committed to the education and welfare of all Coast Guard members and their families, announced today that its annual Tribute to the Eighth Coast Guard District will be held at the National World War II Museum in New Orleans, Louisiana on Friday, March 10, 2017.
Posted on 7 Mar
Coast Guard Foundation announces Scholarship Season now open
The Coast Guard Foundation, a non-profit organization, announced that it has kicked off its 2017 scholarship season. he Coast Guard Foundation, a non-profit organization committed to the education and welfare of all Coast Guard members and their families, announced today that it has kicked off its 2017 scholarship season. Accepting applications from March 1st through April 15th, children of enlisted Coast Guard members may apply for annual scholarships ranging from $1,000 to $5,000.
Posted on 28 Feb
Coast Guard Foundation receives donation from Ice Hockey Team
Coast Guard Foundation announced today that it received a donation from the Guilford High School Ice Hockey Booster Club The Coast Guard Foundation, a non-profit organization committed to the education and welfare of all Coast Guard members and their families, announced today that it has received a donation from the Guilford High School Ice Hockey Booster Club for $2,568, to benefit the Coast Guard Foundation’s Fallen Heroes Fund and Scholarship Fund.
Posted on 25 Feb